Mercury 60 hp bigfoot problems.

Re: 60 HP Mercury/Tracker No Spark? Still Problems. This morning I cleaned the magnets and Stator surfaces and then the engine started and ran for about 2 minuets and then stopped and would not start again with no fire from the coils. Did all the teat but still this problem as intermittant as it is still presists. What can be the problem.

Mercury 60 hp bigfoot problems. Things To Know About Mercury 60 hp bigfoot problems.

The difference between a BigFoot 60 and a regular Merc 60 (in three cylinder engines) is that the lower unit is actually from a 75-90 HP motor which has a 2.33:1 gear set whereas the standard lower unit is a much smaller unit and is fitted with 1.83:1 gear set. The deeper gears allow the same engine to twist a larger diameter prop with more ...I have a Mercury 60 hp 2011, ... The liner separating in my fuel line was a problem with my Mercury 25hp engine. Reply. Pingback: 9 Common Reasons Why an Outboard Dies at Idle – WaterCraft 101. ZvonimirS_74 says: May 6, 2022 at 8:25 am. have a verada 150 from 2007.May 28, 2022 ... Putting the carbs back on the 60hp merc, redo the link n sync and set the idle timing per the mercury service manual instructions Email me: ...Messages. 14. Sep 27, 2017. #1. I replaced the starting battery in my 2015 Mercury Four Stroke 60 HP and accidentally reversed the cables. Didn't see a spark or hear anything and when I turned the key on, nothing happened. I figured out what I had done wrong and corrected it. The engine and gauges all work fine, but it isn't charging the battery.

The thermostat installed on your Mercury Sable's 3.0l engine is what allows coolant to flow from the radiator to the engine. When the thermostat goes out, your engine temperature w...

After approximately 150 hours of use (beginning of summer and end of spring) my [Mercury 60-HP Bigfoot] motor started to have a problem at lower RPM. This was a few weeks after the typical 100 hour maintenance package where the spark plugs and fuel filter were changed. It appears to miss or stutter slightly between 1,200 and 2,500-RPM.60ELPT EFI Bigfoot. This 2005, 60 hp Mercury is made for saltwater. This outboard engine weighs approximately 252 pounds. It has 4 cylinders. The pistons have a 60.8 displacement. The bore width is 2.56" and the stroke length is 2.95". This model has a electric starter and power steering. RPM Information: 5500-6000.

I replaced the water pump on my 2013 merc 60hp 4 stroke efi bigfoot outboard, but when I test with the muffs there is no water coming out of pee hole. Water is coming out from the gear housing where the lower and upper units attach. I have disassembled 3 times to check seals and alignment to no avail.Topic: Mercury 60-HP BIGFOOT: Engine Speed Erratic; Alternator Voltage High: EJO: posted 05-19-2013 03:36 PM ET (US) Today I took my 2008 Montauk 150 with 60HP Bigfoot Merc out for the first time this year with the admiral. This is the first time since I bought the boat that I ran it for longer than an hour. ... So back to my problem ...Mercury 40 hp 2 stroke problems, Mercury 115 2 stroke problems, Mercury 60 hp 2 stroke problems. The 4th Edition of the Marine Electrical Electronics Bible Get your copy and start becoming self sufficient and save money on expensive technician callouts.Mercury 80W-90 Premium Gear Lube is recommended for gearcases for outboards below 75 horsepower. It outperforms automotive gear oil in marine applications by providing maximum protection against excessive wear in the presence of water and helps prevent corrosion and pitting. SAE 90 High-Performance Gear Lube was engineered to …Download Manuals Instantly. Downloadable 60 horsepower 2-stroke and 4-stroke repair manuals are available for all models and years, including the following: Mercury 60 two-stroke engines. Mercury 60 four-stroke motors. 2002 Mercury 60hp 3-cylinder 20" shaft. 2001 Mercury 60hp two-stroke w/tiller handle. 1999-2000 Mercury 60 hp 3 cyl. carbureted.

The four stroke Mercury 60 hp Big Foot price is 65 RRP. The recreational-usage warranty for the F60 FourStroke Big Foot is five years providing it is maintained at an authorised Mercury …. 115 hp outboard 2 stroke manual, mercury 40 hp 4-stroke outboard service manual pdf instantly.

May 2, 2003. Messages. 6,027. Jul 4, 2009. #5. Re: Mercury 50 hp bigfoot with idling / running issues. The id plate is external on the transom bracket. You cannot pull the fault codes without a merc scanner. The control box warning buzzer will tell you if a fault is logged via a series of beeps.

Engine overspeed- that doesn't happen until 6000+ rpm. Low voltage/ electrical- test for volts at battery when the alarm is activated. Low oil pressure- check your oil level (i presume you change your filter regularly?). Usually, the low oil alarm also results in the revs being limited to around 2000 rpm. Coolant sensor failure- the guardian ...Are you experiencing issues with your HP scanner? One common problem that users encounter is outdated or missing drivers. Without the proper drivers installed, your scanner may not...Capacity: 4.2 quarts. Motul Marine Tech 10W-40: A high-performance contender Motul’s offering is a top contender with excellent anti-wear properties As well As shear stability, ideal for pushing your Bigfoot beyond its limits. Prepare for a higher price, however. Price: $60/gallon. Capacity: 4.2 quarts.40-60 FourStroke Engine Maintenance - Changing Engine Oil. A helpful video for maintaining your 40-60 FourStroke Engine. ... Sign up for the Mercury Dockline Newsletter for news, promotions and more . Sign up for the Mercury Marine Newsletter for news, promotions and more. Thank youOur friend Jeff O'Brien from Mercury Marine explains the benefits to rigging a smaller Deep-V boat, like the Tracker Pro Guide V16, with a 60HP Mercury Big F...

Aug 22, 2007. #2. Re: 60HP Mercury EFI alternator problem? Yes, you can check the output with a multimater placed on the battery terminals and the engine idling. If you are only reading in the 12.1-12.9 volt range, the alternator is not charging.Mar 9, 2014 · Re: 2006 Mercury Bigfoot 60hp wont' crank. I take it you mean it wont start, not cranking is the motor is locked up or the starter is fried. Dose it have fire at the plugs and compression. Thats the first things to test and if it passes that then its the fuel system, and that's the fuel pump and the carb. if it cranks and dont start look at the ... Jul 2, 2009 · May 2, 2003. Messages. 6,027. Jul 4, 2009. #5. Re: Mercury 50 hp bigfoot with idling / running issues. The id plate is external on the transom bracket. You cannot pull the fault codes without a merc scanner. The control box warning buzzer will tell you if a fault is logged via a series of beeps. Find Mercury Marine 60 HP Bigfoot (3 Cylinder) Outboard Motor Parts by Serial Number Range. Revise Search: All Models > 60 HP Bigfoot (3 Cylinder) Serial Number Range. 0G590000 - 0G760299 (USA) 0G760300 - 0T979999 (USA) 9973100 - 0P016999 (Belgium) 0P017000 - 0P325499 (Belgium)125. Aug 22, 2012. #3. Re: 2002 60HP Bigfoot 2 stroke - Idle issues. So I spent quite a bit a time working on the motor while boat is docked. Already had some Quicksilver cleaner so sprayed that in the carbs and that certainly made a difference. Changed the internal inline filter..it definitely had some gunk in it.Welcome to our Part Finder! Please select your application and get all our suitable NGK and NTK parts – ranging from spark plugs, glow plugs, ignition coils and leads, to oxygen sensors, air mass and intake manifold pressure sensors, speed & position sensors and EGR valves. Outboard Spark Plugs MERCURY 60 hp - 60 hp - 4 cyl. 4 Stroke EFI.

This engine has a batch fuel injection system, mechanical fuel pump of diaphragm or plunger type, electric start with bendix starter, and capacitor discharge ignition system. A 60.8 cubic inches (995 cc) outboard motor has a cylinder bore of 2.56" (65 mm), piston stroke of 2.95" (75 mm), and maximum power of 60 hp (44.7 kW) at 5750 rpm.So while your bigfoot, opened up, makes say 32 mph burning 6 gph (and I'm just guessing at a top speed, but the difference will be correct), a non-bigfoot 60 would get you an extra 4'ish mph. Or, to put it another way that's easier to understand - bigfoot, 5.3 mpg - non-bigfoot 6 mpg in the same horsepower (12% difference in gas mileage but …

125. Aug 22, 2012. #3. Re: 2002 60HP Bigfoot 2 stroke - Idle issues. So I spent quite a bit a time working on the motor while boat is docked. Already had some Quicksilver cleaner so sprayed that in the carbs and that certainly made a difference. Changed the internal inline filter..it definitely had some gunk in it.Are you experiencing issues with your HP scanner? One common problem that users encounter is outdated or missing drivers. Without the proper drivers installed, your scanner may not...Engine overspeed- that doesn't happen until 6000+ rpm. Low voltage/ electrical- test for volts at battery when the alarm is activated. Low oil pressure- check your oil level (i presume you change your filter regularly?). Usually, the low oil alarm also results in the revs being limited to around 2000 rpm. Coolant sensor failure- the guardian ...Re: 60HP 2 stroke Mercury Bigfoot choke problem Thank you for your reply! The bulb was primed and fules was flowing through the line. he checked that first, actully removed the quick connect on the fuel line (engine side) and direct hooked the line to the motor before he noticed the enricher issue.2. The engine also has a throttle position sensor. This tells the computer how open the throttle is. When you are at idle, it would be fully closed. At full throttle, it's fully open. If the sensor is bad and thinks the engine is at full throttle all of the time, it's going to deliver the fuel needed for full throttle.Delaney Simchuk, Car Insurance WriterJan 19, 2023 Delaney Simchuk, Car Insurance WriterJan 19, 2023 This review is not provided, commissioned or endorsed by any company. Opinions a...

Save up to 70% on 15” Pitch Boat Propellers for your Mercury 60 HP Outboard 4-Stroke, Bigfoot. Quality props from Michigan Wheel, Solas, Turning Point, Stiletto, Quicksilver. ... Mercury 60 HP All Years Outboard Propellers. You Are Viewing Available Prop Pitches For: Manufacturer: Mercury; Horsepower: 60 HP;

Have 60 hp 4 stroke efi Mercury big foot, after about 10-15 min engine starts to stutter at 5000 down to 2500 then up - Answered by a verified Marine Mechanic. ... The problem with this is over time the spring in the valve will get weak or simply break. When that happens the check ball will be free to jump to the outlet side of the valve and ...

40/50/60 FOURSTROKE - Mercury Marine2006 mercury bigfoot 60hp 4 stroke issue. I have a 2006 mercury bigfoot 60hp 4 stroke (new plugs, new and tested fuel injectors as of 3 weeks ago) that ran fine until yesterday. the engine runs fine at idle and runs out to around 5500 rpms and 16mph max (it was running 5800 rpms and 20mph), after about 1-2 minutes of wot it starts to …2006 mercury bigfoot 60hp 4 stroke issue. I have a 2006 mercury bigfoot 60hp 4 stroke (new plugs, new and tested fuel injectors as of 3 weeks ago) that ran fine until yesterday. the engine runs fine at idle and runs out to around 5500 rpms and 16mph max (it was running 5800 rpms and 20mph), after about 1-2 minutes of wot it starts to …22 satisfied customers. 2003 60 HP mercury 4 stroke "BigFoot". Motor starts and runs. 2003 60 HP mercury 4 stroke "BigFoot". Motor starts and runs for about 2 seconds and stalls. It will fire almost every time but then dies immediately even. Charles. Certified Mercury Tech. 5,752 satisfied customers.Mar 26, 2019. #1. I recently bought my 1st boat. (I’m 67). A 2004 Sun Tracker 21’ Party Barge. It has a 2004 Mercury 60hp Bigfoot 2-stroke. It’s had the oil injection system removed so I mix the gas/oil 50:1. I took the boat to the local marine shop and had spark plugs, lower end oil and the water pump & seal replaced.HP scanners are widely used in both personal and professional settings for their reliability and high-quality scanning capabilities. However, like any electronic device, they are n...Unscrew or pop it up. He will see the fitting in fuel tank with a rubber hose clamp to it. Inside of the 90-degree elbow is a check ball and these sometimes get clogged. Remove and clean or replace check ball. These two things will cause suction lines to low pressure pump to collapse also.40-60 FourStroke Engine Maintenance - Changing Engine Oil. A helpful video for maintaining your 40-60 FourStroke Engine. 40-60 FourStroke Engine Maintenance - Changing Fuel Filter. ... Mercury Marine is a division of Brunswick Corporation.HP scanners are widely used in both personal and professional settings for their reliability and high-quality scanning capabilities. However, like any electronic device, they are n...

Jun 15, 2011. Messages. 2. Jun 15, 2011. #1. All, I have a 20" Harris Flotebote w/60 HP Merc Bigfoot - ran great last year. 5000RPM was full throttle. This year I took it out for the first time and can only get 4000RPM at full throttle. I figured it was a fuel delivery issue so i replaced the fuel line from tank to engine, put new fuel filter ...2023 Mercury Marine® FourStroke 60 HP EFI SAVE OVER $1,300 ON THIS NEW MERCURY 60ELPT EFI 4-STROKE OUTBOARD! This is a brand new engine with a 3-year factory warranty. Engine features: 4-cylinder 4-stroke engine with EFI, electric start, remote steering, power trim, and shaft length designed for boats with 20” transoms.Mercury 80W-90 Premium Gear Lube is recommended for gearcases for outboards below 75 horsepower. It outperforms automotive gear oil in marine applications by providing maximum protection against excessive wear in the presence of water and helps prevent corrosion and pitting. SAE 90 High-Performance Gear Lube was engineered to …Feb 17, 2023. #1. the outboard is a 2013 mercury 60 horse bigfoot, this is a 4 stroke EFI motor. the motor has no crank at all and no tilt or trim, im testing the tilt and trim strictly from the motor and not on the hull. everytime you try using the tilt either up or down the relay clicks, sometimes when you crank a relay clicks, i havent ...Instagram:https://instagram. welsh corgi oregonallegheny county welfare departmentfuel pump relay location 2004 ford expedition5 and below clifton nj Hello everyone, I bought Mercury 4Stroke EFI BigFoot 60 hp 2007 three months ago...While negotiation with the former owner we made a small tour with the boat but i did not notice the problem since it was 5 minute tour... It runs great at idle and at low rpms in first 15 - 20 minutes and... keith reed jr. first wifege 24922 code list 125. Aug 22, 2012. #3. Re: 2002 60HP Bigfoot 2 stroke - Idle issues. So I spent quite a bit a time working on the motor while boat is docked. Already had some Quicksilver cleaner so sprayed that in the carbs and that certainly made a difference. Changed the internal inline filter..it definitely had some gunk in it.Aug 12, 2016. #5. I have been experiencing the exact same issue. Well, I just figured it out and now it steers real easy. There is a screw on the starboard side of the pivot housing. Back that screw out about 1/4 turn and see if that's it. That's a ease of steering adjustment, I guess. I hope that solves your problem. otter tail county jail There are four types of starting problems: Engine will not start; Engine cranks slowly but will not start; ... 2002-2005 Mercury 40/50/60 ELPT Bigfoot 4-Stroke Mercury 6 HP Mercury 8 HP Mercury 8 HP Sailmate Mercury 9.9 HP Mercury 9.9 HP Sailpower, XR10/MAG 10/Viking 10 Mercury Sea Pro/Marathon 10Mar 16, 2013. #1. I have a 2007 60hp 4 stroke efi that keeps losing fuel pressure. I can turn the ignition on and get 42psi at the VST schrader valve. I can run the motor for anywhere between 1 minute and 1 hour at normal speeds under a load with no loss of power and then the fuel pressure will drop to 5 psi then start bouncing between 5 and 30 ... This was tough video to make. My Bass Tracker with a 60 hp Mercury 4 stroke outboard motor is having a major issue. I do solve one problem with the ole 60 hp...